User manual DOLMAR ES-32 A PARTS LIST 2003-11

[. . . ] (Refer to instruction manual of engine) Sticking of impeller (Disassemble & clean) Pumping volume is small. Entrance of air at suction side (Check piping at suction side) Drop of engine output (Repair) Breakage of mechanical seal (Replace mechanical seal) High suction lift (Lower) Thin or long or kink of hose (Thicken or shorten or straighten) Leak of water from water passage (Stop leak) Clogging of foreign substance in impeller (Disassemble & clean) Wear of impeller (Replace impeller) Pump does not self-prime. Suction of air at suction side (Check piping at suction side) Insufficient priming water inside pump casing (Prime fully) Imperfect tightening of drain cock (Tighten the 2 plugs completely) Imperfect revolution of engine (Repair engine) Entrance of air from mechanical seal (Replace mechanical seal) Remove spark plug, and with its metal part touching the cylinderhead, try to Do sparks fly in spark plug?If compression is low, check the tightness of the spark plugs and other members, and tighten all loose members. [. . . ] If fuel is spilt, wipe it away carefully and wait until the fuel has dried before starting the engine. After refueling, make sure that the fuel cap is secured to prevent spillage. Do not use around dry brush, twigs, cloth rags, or other flammable materials. Keep the engine at least 3 feet (1 meter) away from buildings or other structures. Keep the engine away from flammables and other hazardous materials (trash, rags, lubricants, explosiver). For handheld engine : The Emissions Compliance Period referred to on the Emissions Compliance label indicates the number of operating hours for which the engine has been shown to meet Federal emission requirements. An Air Index Information hang tag was supplied to this engine in accordance with the emission regulations of the California Air Resources Board. The bar graph on the hang tag shows the emissions performance of this engine. The bar graph can be used to compare the emissions performance with other available engine. The following durability description is to provide you with information relating to the emission durability period of the engine. The Air Index Information hang tag must remain on the engine or on the equipment until it is sold to the ultimate purchaser. Any warranted part that is scheduled for replacement as required maintenance in the written instructions required by subsection (d) must be warranted for the period of time prior to the first scheduled replacement point for that part. If the part fails prior to the first scheduled replacement, the part must be repaired or replaced by the engine manufacturer according to Subsection (4) below. Any such part repaired or replaced under warranty must be warranted for the remainder of the period prior to the first scheduled replacement point for the part. (4) Repair or replacement of any warranted part under the warranty must be performed at no charge to the owner at a warranty station. (5) Notwithstanding the provisions of Subsection (4) above, warranty services or repairs must be provided at all manufacturer distribution centers that are franchised to service the subject engines. (6) The owner must not be charged for diagnostic labor that leads to the determination that a warranted part is in fact defective, provided that such diagnostic work is performed at a warranty station. (7) The manufacturer is liable for damages to other engine components proximately caused by a failure under warranty of any warranted part. (8) Throughout the emissions warranty period defined in Subsection (b) (2), the manufacturer must maintain a supply of warranted parts sufficient to meet the expected demand for such parts. (9) Any replacement part may be used in the performance of any warranty maintenance or repairs and must be provided without charge to the owner. Such use will not reduce the warranty obligations of the manufacturer. (10) Add-on or modified parts that are not exempted by the Air Resources Board may not be used. [. . . ] INTERVAL : Every 8 hours (daily) : Every 8 hours (refill daily up to upper limit) : Initial 20 hours and every 50 hours afterward : Every 8 hours (daily) : Every 8 hours (daily) : Every 8 hours (daily) : Every 50 hours (monthly) : Every 50 hours (monthly) : Every 200 hours (yearly) : Every 200 hours (yearly) : Every 200 hours : Every reassembling EMISSION COMPONENT DEFECT WARRANTY COVERAGE - This emission warranty is applicable in all States, except the State of California DOLMAR GmbH North American Division, (herein "Dolmar") warrant to the initial retail purchaser and each subsequent owner, that this utility equipment engine (herein "engine") was designed, built, and equipped to conform at the time of initial sale to all applicable regulations of the U. Environmental Protection Agency (EPA), and that the engine is free of defects in materials and workmanship which would cause this engine to fall to conform with EPA regulations during its warranty period. For the components listed under PARTS COVERED, the dealer or service center authorized by Dolmar will, at no cost to you, make the necessary diagnosis, repair, or replacement necessary to ensure that the engine complies with applicable U. EMISSION COMPONENT DEFECT WARRANTY PERIOD The warranty period for this engine begins on the date of sale to the initial purchaser and continues for a period of 2 years. [. . . ]